Pages: [1]   Go Down

AuthorTopic: Steering Slack  (Read 1697 times)

0 Members and 1 Guest are viewing this topic.

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« on: December 03, 2006, 20:17:09 »
hi on me 90 200 tdi 59000miles i have slack from my steering box to my drop arm and if i adjust it it just makes it tight to turn any ideas.Ray
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline ferret

  • Posts: 86
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #1 on: December 03, 2006, 20:37:32 »
Get someone to wobble the steering wheel and check the steering colum uj's for play. Also make sure the drop arm is not loose as the nut needs to be very tight( as in tightened with a breaker bar.) Check ball joint on drop arm for play while someone is wobbleing the steering.To adjust the box you need to slacken the lock nut on the top of the box and then turn the allen screw in until it stops then back off slightly and hold there while you do the lock nut back up.

hope this helps..
Logged
aka paul*

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #2 on: December 03, 2006, 20:44:22 »
tryed tightning the big nut, ujs fine ,i adjusted the allen key bolt but it made my steering go tight
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline extreme90

  • Regional Rep
  • *
  • Posts: 3219
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • say no to orange extreme bits !!
  • Referrals: 0
Steering Slack
« Reply #3 on: December 03, 2006, 20:48:28 »
mite be the drop arm ball joint
mine needs replacing again  :roll:  timberdog will vouch for that  :oops:
danny
Logged
Dan Thomas,                  Matt Price
Team Relentless " No half measures "
Bobtailed Auto Td5 90 comp truck........... Got more tricks than a magician !!

http://www.Devon 4x4.co.uk >> for all your truck needs and more !!
http://www.Gigglepin4x4.net >> For when the going gets tuff, and one motor just isnt good enough !!!
http://www.gwynlewis4x4.co.uk >> the guy everyone forgets, but he doesnt forget your custom.

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
Steering Slack
« Reply #4 on: December 03, 2006, 20:50:56 »
are you adjusting the steering box in the straight ahead position or turned to one side?

if ur doing it in the straight ahead position no wonder its going tight,do it with a bit of left or right lock
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #5 on: December 03, 2006, 21:02:17 »
straight ahead , if i am stationary i can turn the steering wheel a lot from side to side  before the wheels move .the skack is from the box to the drop arm.Its ugly to drive on the road wife has refused to drive it.Imust say its a bit scary
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline extreme90

  • Regional Rep
  • *
  • Posts: 3219
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • say no to orange extreme bits !!
  • Referrals: 0
Steering Slack
« Reply #6 on: December 03, 2006, 21:09:33 »
are u sure ? mines exactly the same as that and is the drop arm ball joint  :?
danny
Logged
Dan Thomas,                  Matt Price
Team Relentless " No half measures "
Bobtailed Auto Td5 90 comp truck........... Got more tricks than a magician !!

http://www.Devon 4x4.co.uk >> for all your truck needs and more !!
http://www.Gigglepin4x4.net >> For when the going gets tuff, and one motor just isnt good enough !!!
http://www.gwynlewis4x4.co.uk >> the guy everyone forgets, but he doesnt forget your custom.

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #7 on: December 03, 2006, 21:12:18 »
how can i test that joint pls
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
Steering Slack
« Reply #8 on: December 03, 2006, 21:13:44 »
Quote from: "bombx3"
straight ahead , if i am stationary i can turn the steering wheel a lot from side to side  before the wheels move .the skack is from the box to the drop arm.Its ugly to drive on the road wife has refused to drive it.Imust say its a bit scary

Try adjusting the steering box with a bit of lock on :wink:
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #9 on: December 03, 2006, 21:17:31 »
could you tell me why you need lock to adjust pls
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
Steering Slack
« Reply #10 on: December 03, 2006, 21:24:03 »
The steering box gets worn the most in the straight ahead position so if u adjust the box in the straight ahead position you are taking out more slack than required,

If you do it on lock ur taking that actual play out the box rather than just horsing the box up
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #11 on: December 03, 2006, 21:27:16 »
thanks that makes a lot of sense i wll try it now,how can i test drop arm for movement .back in 5mins
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline extreme90

  • Regional Rep
  • *
  • Posts: 3219
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • say no to orange extreme bits !!
  • Referrals: 0
Steering Slack
« Reply #12 on: December 03, 2006, 21:33:35 »
with engine running get some one to waddle the wheel and u watch to see if the arm or ball join move up or down  :roll:
mine does like mad  :oops:
danny
Logged
Dan Thomas,                  Matt Price
Team Relentless " No half measures "
Bobtailed Auto Td5 90 comp truck........... Got more tricks than a magician !!

http://www.Devon 4x4.co.uk >> for all your truck needs and more !!
http://www.Gigglepin4x4.net >> For when the going gets tuff, and one motor just isnt good enough !!!
http://www.gwynlewis4x4.co.uk >> the guy everyone forgets, but he doesnt forget your custom.

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #13 on: December 03, 2006, 21:37:11 »
think we got it the arm moves side to side in the box
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch

Offline bombx3

  • Posts: 366
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Steering Slack
« Reply #14 on: December 03, 2006, 21:56:10 »
think we got it the arm moves side to side in the box ,do you no how to stop this pls.Ray
Logged
_______________________________________
 defender 200 tdi. 59,000m ,winch .spots,front rollcage,rear internalcage,snorkel,undersealed,polybushed,tweaked motor,roof tent ,muds ,noise reducers,stainless exhaust,3"lift+4 shocks,chequered plating,12 change cd ,cb,sound proof kit,sunroof,landrover carpet,wading kit.hilift jack,rock sliders jackable,axle breather kit,folding forward facing rear,roof rack to carry roof tent, seat,electric seat warmer.tilt meter,full stainlees exhaust,fire exstingsher thatcham alarm ,immobolizer , fsh and only used on sundays once a month,now 38" boggers,wide ange props,4pin diff ,ashcroft shafts,qt steering bar ,winch
Pages: [1]   Go Up
 





SimplePortal 2.3.5 © 2008-2012, SimplePortal