Pages: [1]   Go Down

AuthorTopic: DEAD DISCO part two  (Read 706 times)

0 Members and 1 Guest are viewing this topic.

Offline Oz

  • Posts: 357
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Guildford
  • Referrals: 0
DEAD DISCO part two
« on: September 15, 2007, 21:53:28 »
Ok guys and gals.
I had turbo and intercooler probs + lots of smoke..

Basically my turbo was drinking the oil up and spiting it in to the intecooler.. so i fort i would take it off and have a look at it. After inspecting it to finds that the blades and bearings were way past there use by date!!! :(

So i replaced it with a second hand turbo that i know was running fine b4 i put it on my disco. Also cleaned the intercooler and pipes. fited new air filter, oil filter and oil.
After letting her warm up i gave her a test run. discoverd bottum intercooler hose was not on correctly. noticed oil that had come out of it. checked the intercooler and there was about half an inch of oil in the bottom of it and all the pipes were oilly.

Any one got any ideas on what this problem could be?

cheers guys
Logged

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
Re: DEAD DISCO part two
« Reply #1 on: September 15, 2007, 22:21:18 »
Quote from: "Oz"
Ok guys and gals.
I had turbo and intercooler probs + lots of smoke..

Basically my turbo was drinking the oil up and spiting it in to the intecooler.. so i fort i would take it off and have a look at it. After inspecting it to finds that the blades and bearings were way past there use by date!!! :(

So i replaced it with a second hand turbo that i know was running fine b4 i put it on my disco. Also cleaned the intercooler and pipes. fited new air filter, oil filter and oil.
After letting her warm up i gave her a test run. discoverd bottum intercooler hose was not on correctly. noticed oil that had come out of it. checked the intercooler and there was about half an inch of oil in the bottom of it and all the pipes were oilly.

Any one got any ideas on what this problem could be?

cheers guys

clean the intercooler again for a start
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline Oz

  • Posts: 357
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Guildford
  • Referrals: 0
DEAD DISCO part two
« Reply #2 on: September 16, 2007, 10:46:11 »
Come on guys some one must have an idea? lol
Logged

Offline clbarclay

  • Posts: 1615
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
DEAD DISCO part two
« Reply #3 on: September 16, 2007, 11:25:44 »
Where does the engine cankcase breather go to? I assume this is a TDi engine.

On the VMs fitted to RRC the breather went to the airfilter, so if the engine was breathing heavy it could put a significant quantity of oil into the air intake ahead of the turbo.
Logged
Chris

Various range rovers from 1986 to 1988 in various states
Locost sports car based on mk2 escort - currently working on brakes, fuel and wiring

Offline Oz

  • Posts: 357
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Guildford
  • Referrals: 0
DEAD DISCO part two
« Reply #4 on: September 16, 2007, 11:28:02 »
yes sorry its a 300tdi. could'nt see any oil on the air inlet side of the turbo up to the air box. nor in the air inlet side of the turbo its self
Logged

Offline paul and sam

  • Posts: 196
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
DEAD DISCO part two
« Reply #5 on: September 16, 2007, 18:39:45 »
what about the erg plate? found all items full of crud
Logged

Offline Xtremeteam

  • Regional Rep
  • *
  • Posts: 6476
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Its just the way i roll
    • lampeter, west wales
  • Referrals: 0
DEAD DISCO part two
« Reply #6 on: September 16, 2007, 19:24:39 »
is there oil in the inlet manifold?

if not clean the intercooler out again
Logged
Mike
I can Drive.. You can criticize..
I too can criticize like you.. but can you Drive like me??

Offline Oz

  • Posts: 357
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
    • Guildford
  • Referrals: 0
DEAD DISCO part two
« Reply #7 on: September 16, 2007, 23:10:26 »
There is a lil bit and its clean oil... not old oil left in it ill clean it out again 2moz see what happens
Logged
Pages: [1]   Go Up
 





SimplePortal 2.3.5 © 2008-2012, SimplePortal