Pages: [1]   Go Down

AuthorTopic: engine swap  (Read 1112 times)

0 Members and 1 Guest are viewing this topic.

Offline gingernutsv8

  • Posts: 100
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
engine swap
« on: October 25, 2009, 17:15:59 »
I have just swapped my 3.9 engine in my rangie as the old one dropped a piston i changed it to the later engine with the serpentine belt it runs fine on gas but when on petrol it has a miss has any body got a clue what could be wrong
Logged
If it ain't broke hit it with a big hammer then it will be.

Offline Rossko

  • Posts: 297
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Re: engine swap
« Reply #1 on: October 29, 2009, 18:29:40 »
The  EFI system earths via some eyelets at the rear of the LHS head, easy to miss one of those.
Fuel pump, filter, regulator, AFM, ECU, injectors are not used by simple gas system, so possible faults there.
Lambda sensors (if fitted) may or may not be used by gas.  Very often it uses only one, leaving room for the other one to broke for petrol.
Logged
GLASS

Offline Range Rover Blues

  • Moderator
  • ***
  • Posts: 15218
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +3/-0
    • South Yorkshire
  • Referrals: 0
Re: engine swap
« Reply #2 on: November 01, 2009, 02:05:55 »
Well my fist question would be did it run ok on the old engine?

If so then did you keep any parts of the old engine? inlet/injestors etc or was the replacement dropped in with all the EFi in place.

Check plugs, timing, then as Rossko says check the sensors (by sustitution for a known good part).

What make of gas conversion, what type?
Logged
Blue,  1988  Range Rover 3.5 EFi with plenty of toys bolted on
Chuggaboom, 1995 Range Rover Classic
1995 Range Rover Classic Vogue LSE with 5 big sticks of Blackpool rock under the bonnet.

Offline kemo

  • Posts: 12
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Re: engine swap
« Reply #3 on: December 01, 2009, 13:19:05 »
check the timing as my 3.9 lpg runs better at 8 degs advanced if i run on petrol
Logged

Offline gingernutsv8

  • Posts: 100
  • Attack: 100
    Defense: 100
    Attack Member
  • Karma: +0/-0
  • Referrals: 0
Re: engine swap
« Reply #4 on: December 01, 2009, 15:40:01 »
found problem wire broke on no7 injector connected together and runs perfect now thanks people
 
Logged
If it ain't broke hit it with a big hammer then it will be.
Pages: [1]   Go Up
 





SimplePortal 2.3.5 © 2008-2012, SimplePortal